载马钱子碱纳米粒的微球系统的制备与初步评价
Preliminary Evaluation and Preparation of Brucine Nanoparticles-in-microsphere System
-
摘要: 目的 制备包载马钱子碱纳米粒的壳聚糖微球系统（Brucine nanoparticles-in-microsphere system，Brucine-NiMS），以期获得一种降低突释作用用于关节腔注射的长效制剂。方法 以牛血清白蛋白（BSA）为材料，采用去溶剂化法制备载马钱子碱的纳米粒（Brucine nanoparticles， Brucine-Nps）。再以壳聚糖(CS)为载体，利用喷雾干燥法将纳米粒包载于壳聚糖微球系统中。在电镜下观察Brucine-NiMS的外观，并测定其体外释放特性。结果 Brucine-NiMS的处方为：CS的型号为600 kDa，CS醋酸溶液的浓度为1%，BSA与CS的比例为1∶5。喷雾干燥的条件为：蠕动泵速度为20%，进口温度为120 ℃，Q-Flow为40 mL/h。在此条件下制备的Brucine-NiMS的包封率、载药量和粒径分别为97.35%、3.17%和1.48 μm。Brucine-NiMS外观圆整，性质稳定。结论 Brucine-NiMS制备方法稳定可控，为开发药物新剂型提供了新的思路。Abstract: OBJECTIVE To find a long-acting preparation which can reduce the burst effect in intra-articular injection by preparing the brucine nanoparticles-in-microsphere system (Brucine-NiMS).METHODS Brucine nanoparticles (Brucine-Nps) were prepared by desolvation of BSA. Chitosan was used as an carrier and the nanoparticles were contained in the microsphere system by the spray drying method. The appearances of Brucine-NiMS were observed under the electron microscope and then the in vitro release characteristics were determined.RESULTS The formulation of Brucine-NiMS was as follows: BSA/CS (600KDA) 1∶5 (w/w) and the concentration of CS in the acetic acid was 1%. The spry drying conditions were as follows: The speed of the peristaltic pump was adjusted to 20%， the temperature of inlet was 120 ℃， and Q-Flow was 40 mL/h. The envelop rate， drug loading and particle sizes of Brucine-NiMS were 97.35%， 3.17% and 1.48 μm respectively. The appearance of Brucine-NiMS was rounding and the nature was stable.CONCLUSION The preparation method of Brucine-NiMS is stable and controllable， providing a new way to develop new dosage forms of drugs.
-
Key words:
- brucine /
- nanoparticles-in-microsphere system /
- spray drying technique
-
[1] 肖璐，陈志鹏，蔡宝昌，等．用于关节腔注射的缓控释系统研究进展[J]．中国医院药学杂志，2011， 31（9）：768-772． [2] Xiao L， Chen ZP，Cai BC， et al. Research advances on slow/controlled release system used in intra-articular injection[J]. Chin J Hosp Pharm， 2011， 31(9): 768-772. [3] Shi M， Yang YY， Chaw CS， et al. Double walled POE/PLGA microspheres: encapsulation of water-soluble and water-insoluble proteins and their release properties[J]. J Control Release， 2003， 89(2): 167-177. [4] 陈娟，陈志鹏，肖璐，等．马钱子碱白蛋白纳米粒的制备与初步评价[J]．南京中医药大学学报，2011， 27（6）：555-557． [5] Chen J， Chen ZP， Xiao L， et al. Evaluation and preparation of Brucine-BSA-NPs[J]. J Nanjing Univ Tradit Chin Med， 2011， 27(6): 555-557. [6] 吕维玲，胡晋红，朱全刚，等．氢溴酸东莨菪碱纳米粒-微球系统的研制[J]．药学学报，2010， 45（7）：914-919． [7] Lv WL， Hu JG， Zhu QG， et al. Preparation of scopolamine hydrobromide nanoparticles-in-microsphere system[J]. Acta Pharm Sin， 2010， 45(7): 914-919. [8] Li FQ， Yan C， Bi J， et al. A novel spray-dried nanoparticles-in-microparticles system for formulating scopolamine hydrobromide into orally disintegrating tablets[J]. Int J Nanomedicine， 2011， 6: 897-904. [9] 陈志鹏，刘文，陈洪轩，等．用于关节腔注射的马钱子碱壳聚糖温敏凝胶的研究[J]．药学学报，2012， 47（5）：652-656． [10] Chen ZP， Liu W， Chen HX， et al.Brucine chitosan thermosensitive hydrogel for intra-articular injection[J]. Acta Pharm Sin， 2012， 47(5): 652-656. -
点击查看大图
计量
- 文章访问数: 677
- HTML全文浏览量: 2
- PDF下载量: 705
- 被引次数: 0
下载:
